VW Golf VI 1.6 TDI, 105 PS, 5-speed manual (2009–2013)

Research for this car

• Generation guide VW Golf 6 (2008-2013): known problems and buying guide

  Buy only with proof of timing chain and DSG work. The chain, the GTI tensioner and the dry DSG cause the big bills.

• Engine guide VW 1.6 and 2.0 TDI (EA189) diesel engines: problems, costs and what to check

  Recall work, EGR and DPF faults and injector repairs are common. Buy with recall proof, a belt invoice and a clean fault memory.

Known issues for this car

Before you buy this car

From the generation guide

1. Clear the scuttle drains under the wipers. Lift the floor mat and smell for damp. Water in the footwell is a reason to check the fuse box and the control units in the driver footwell for corrosion.
2. Check springs and dampers, and drive shaft boots. Torn boots are normal wear from about 150,000 km.

From the engine guide

1. Recall paperwork (no scanner). Ask the dealer for a record of the software update, and of the flow straightener on a 1.6. Bad: no record.
2. Fault memory (needs a scanner). Bad: EGR codes P0401 or P0402, turbo codes P2563 or P2564, or DPF codes such as P2002.
3. Test drive. Bad: judder, lost power or limp mode.
4. Injectors (no scanner). Ask whether the injectors were replaced or revised. Bad: rough running with no injector work on record.
5. DPF (no scanner). Ask how the car was driven and whether the filter was cleaned. Bad: a DPF warning lamp, or short trips only.
6. Coolant (engine cold). Check the level and look for an exhaust smell in the cabin. Bad: any coolant loss. The EGR cooler is a common cause.
7. Timing belt invoice. Bad: no dated invoice for the belt, tensioner and water pump, or past 210,000 km or 5 years with no change.
8. Turbo (needs a scanner). On a 2.0 TDI past about 150,000 km. Bad: boost codes or oil leaks at the turbo.
9. Flywheel (manual only). Drive in 2nd gear at about 1,400 rpm. Bad: a rattle.

Running costs

ADAC figures for 15,000 km a year over 60 months

ADAC versions